What are the precautions of using Dyneema rope?

The surface of the Dyneema rope body is added with the lubricating factor, and the coating of the rope surface is improved. The smooth coating makes the rope durable, the color is long-lasting, and prevents wear and fading. So, what are the precautions to use the Dyneema rope? The next is some introduction.

Here is the content list:

• Observe the weather

• Pay attention to keep

• Check the breakage

• Strictly knocking

• Maintain tension

• Slow traction

• Pay attention to check

Observe the weather

Before spreading the rope to observe the weather, especially the wind direction, to determine the rope first into which side of the sheave, to prevent when two rope spreading finished stranding, especially first put a rope should be as soon as possible to draw tight, to prevent the two rope stranding.

Pay attention to keep

Winding recovery Dyneema rope spool frame should be wrapped with cloth and other things, to stop Dyneema rope and iron and another direct contact, to prevent damage to HMPE fishing rope, in construction, use, storage, transportation, do not allow unauthorized cutting Dyneema rope, must strengthen the storage and use.

Check the breakage

In the process of use found sheath broken, with plastic tape winding, on the discovery of the inner layer of Dyneema silk broken strands, should be identified by the command or relevant personnel cut off and rejoin, rejoin using lap method, with Dyneema silk made of small line, with a continuous wrap tight a few turns sewing a few stitches, and then outside with plastic tape winding, shall not be directly tied buckle.

Strictly knocking

The connection between rope and rope and rope and guide rope must use a bending resistant connector to facilitate the construction. In the construction shall not use the small rope to press the Dyneema rope or knock the HMPE rope with hardware. In addition, in the traction process is strictly prohibited to lose grinding, only allowed to traction forward, otherwise, it will cause the sheath and the inside of the Dyneema like detachment, and the formation of "lantern", easy to pull off.

Maintain tension

In the process of traction, to slow exercise, and maintain a certain tension, lead the rope to hold the Dyneema rope cannot exceed 500㎏, Synthetic rope to lead the rope cannot exceed 1000㎏. In front of the winch mill should not place the bottom carriage, if must place, should be far from the winch mill.

Slow traction

When the traction guide rope is about to arrive at the payoff sheave should stop immediately, the small sheave open, guide rope put into the big sheave slot, do not allow the guide rope to go board and so on over the small sheave, the small sheave can only go minima rope anti-bending connector, over the small sheave must pay attention to observation, and slow traction. When traction guide rope with Dyneema rope, must pay attention to the towing rope strand strength, should make measures, must be flexible and reliable when installing the rotating connector.

Pay attention to check

To the soft shackle rope rental before to check, especially in the use of the process, because the spreading speed is slow, must set up a person to check it, to have a suspicion or have problems to deal with in time, after use, return to the rental must also be checked.

Zhejiang Hailun Rope&Net Co., Ltd reminds you to read the above precautions carefully before using Dyneema rope.